Author Topic: Centre Stand spring  (Read 4496 times)

Online Biggles

  • NatRally 2018 - Mackay
  • "Top Dog" 10000 club
  • *
  • Posts: 14059
  • Thanked: 2508 times
  • Bridgeman Downs, Brisbane
Centre Stand spring
« on: June 07, 2013, 03:08:04 PM »
I just put Ruby on her centre stand (needed to test the hernia).

While standing on my head checking the oil, I noticed there is a smaller, inner spring on the stand.  The outer is connected at both ends, but the inner bottom hook is not engaged.

Can someone check theirs and see if that inner spring is hooked to the same point as the large outer one, please?

Or what is it attached to?  Is it a spare?  (Always carry a spare, I reckon)    :grin

TIA
For the modern man who lives in the city, riding a bike might be one of the only ways to escape the humdrum monotony. To take off and ride. To be both at one with nature and one with the bike. To feel masculine. Adam Piggott

OzSTOC #16  STOC #6135  FarR #509  IBA #54927
 

Offline bluehonda

  • Brad
  • Full Member
  • ***
  • Posts: 247
  • Thanked: 1 times
  • ST Pilot
Re: Centre Stand spring
« Reply #1 on: June 07, 2013, 03:16:50 PM »
 :blk13

Hi Biggles

The inner spring is attached both ends to the same mount points as the outer spring

Brad
2007 Honda ST1300
1999 Honda ST1100 (till it's sold)
Yamaha DT230
Montessa Cota 314R
Suzuki DRZ400E

Ride like your life depends on it
The older I get the better I was!
 

Online Biggles

  • NatRally 2018 - Mackay
  • "Top Dog" 10000 club
  • *
  • Posts: 14059
  • Thanked: 2508 times
  • Bridgeman Downs, Brisbane
Re: Centre Stand spring
« Reply #2 on: June 07, 2013, 03:19:30 PM »
Now that's the sort of service I could get used to!  Nine minutes to get an answer!

Gotta love this Forum.

Thanks for that, Brad.  I'll hook it up.  Didn't want to do it without checking in case I broke something.  I deduce it's a safety back-up so the stand doesn't fall and drag if the primary one failed.

I wonder when the inner one came unhooked.  I'll keep an eye on it when I pulled her up in future.
For the modern man who lives in the city, riding a bike might be one of the only ways to escape the humdrum monotony. To take off and ride. To be both at one with nature and one with the bike. To feel masculine. Adam Piggott

OzSTOC #16  STOC #6135  FarR #509  IBA #54927
 

Offline alans1100

  • 1999 ST1100A
  • UNBELIEVABLE "5000 Posts" Member
  • ****
  • Posts: 6250
  • Thanked: 1161 times
  • Alan, Peterborough, SA
Re: Centre Stand spring
« Reply #3 on: June 07, 2013, 03:33:09 PM »
I have a similar issue.

Sometime last year I noticed that the main spring was not attached at one end. No way could I get that back on. So I removed it and noticed that the main spring was bent. Not sure how that happened, may have been like that since I had it. I ordered a new spring which as yet has to be fitted. Relying on smaller back up spring at the moment. It can wait until I the fork seals get done at the bike shop.
1999 :bl11  2004 :13Candy

FarRider #921- BR15, BR17, CR1

 

Online Biggles

  • NatRally 2018 - Mackay
  • "Top Dog" 10000 club
  • *
  • Posts: 14059
  • Thanked: 2508 times
  • Bridgeman Downs, Brisbane
Re: Centre Stand spring
« Reply #4 on: June 07, 2013, 04:05:09 PM »
I have a similar issue.

Sometime last year I noticed that the main spring was not attached at one end. No way could I get that back on.

It's stating the obvious, but did you try with the centre stand retracted?  The spring is under less tension then.
For the modern man who lives in the city, riding a bike might be one of the only ways to escape the humdrum monotony. To take off and ride. To be both at one with nature and one with the bike. To feel masculine. Adam Piggott

OzSTOC #16  STOC #6135  FarR #509  IBA #54927
 

Offline alans1100

  • 1999 ST1100A
  • UNBELIEVABLE "5000 Posts" Member
  • ****
  • Posts: 6250
  • Thanked: 1161 times
  • Alan, Peterborough, SA
Re: Centre Stand spring
« Reply #5 on: June 07, 2013, 04:14:24 PM »


It's stating the obvious, but did you try with the centre stand retracted?  The spring is under less tension then.

Tried that and lost some skin as the tool slipped off the spring.
1999 :bl11  2004 :13Candy

FarRider #921- BR15, BR17, CR1

 

Online StinkyPete

  • Defected to a BMW
  • NR2016 Group
  • UNBELIEVABLE "5000 Posts" Member
  • *
  • Posts: 6546
  • Thanked: 2952 times
  • Blackwood, SA
Re: Centre Stand spring
« Reply #6 on: June 07, 2013, 06:02:53 PM »
I learned a great trick for stretching a tension spring, to get it back on the hooks without too much difficulty.

Stick one end of the spring in a vice, push it right over to one side, and poke a washer in one of the gaps between the coils.
Push in the opposite direction and stick a washer in the opposite gap
Continue to do this, adding washers until the spring is long enough to enable you to hook both ends on the hooks.
When you extend the spring by putting the centre-stand all the way down, all the washers fall out.
 :grin :grin
IBA #59146   OzLapper 2012 & 2019

BSA M21 600cc single (1948)
Yamaha XS650  (The Black Wobbler)
Yamaha XJR1300 (Rocket Ship)
Honda ST1300 (Beautiful Bike)
BMW R1200RT (Technically Perfect)
 

Offline Brock

  • Tardis Tech
  • UNBELIEVABLE "5000 Posts" Member
  • ****
  • Posts: 8724
  • Thanked: 1697 times
  • White is the fastest
Re: Centre Stand spring
« Reply #7 on: June 07, 2013, 06:10:12 PM »
Great tip Pinky
Brock
Asian Correspondent
2003 Honda ST1100PY



Ulysses #32829
STOC #8239
OzSToc # ??
Kinross WA
 

Online StinkyPete

  • Defected to a BMW
  • NR2016 Group
  • UNBELIEVABLE "5000 Posts" Member
  • *
  • Posts: 6546
  • Thanked: 2952 times
  • Blackwood, SA
Re: Centre Stand spring
« Reply #8 on: June 07, 2013, 06:13:06 PM »
Great tip Pinky

Not just a pretty face.....     8)
IBA #59146   OzLapper 2012 & 2019

BSA M21 600cc single (1948)
Yamaha XS650  (The Black Wobbler)
Yamaha XJR1300 (Rocket Ship)
Honda ST1300 (Beautiful Bike)
BMW R1200RT (Technically Perfect)
 

Offline bluehonda

  • Brad
  • Full Member
  • ***
  • Posts: 247
  • Thanked: 1 times
  • ST Pilot
Re: Centre Stand spring
« Reply #9 on: June 07, 2013, 06:21:15 PM »
Hey Biggles
Can you notice that anything is different with both springs attached?

Brad
2007 Honda ST1300
1999 Honda ST1100 (till it's sold)
Yamaha DT230
Montessa Cota 314R
Suzuki DRZ400E

Ride like your life depends on it
The older I get the better I was!
 

Online Biggles

  • NatRally 2018 - Mackay
  • "Top Dog" 10000 club
  • *
  • Posts: 14059
  • Thanked: 2508 times
  • Bridgeman Downs, Brisbane
Re: Centre Stand spring
« Reply #10 on: June 08, 2013, 10:04:37 PM »
Hey Biggles
Can you notice that anything is different with both springs attached?

Brad

Sorry Brad- haven't done the job yet- had my hands full these past 24 hours with the FarRide.

For the modern man who lives in the city, riding a bike might be one of the only ways to escape the humdrum monotony. To take off and ride. To be both at one with nature and one with the bike. To feel masculine. Adam Piggott

OzSTOC #16  STOC #6135  FarR #509  IBA #54927